2013 16 (M.) Asboat Yacht Building LTD Diesel Duck 50 Sedan

DIESELDUCK 50 SEDAN LONG RANGE STEEL TRAWLER

GEORGE BUEHLER DESIGN

ASBOAT YACHT BUILDING SPECIFICATION

UNDER MAIN DECK:

- Master cabin
- Shower, toilet
- Forward guest cabin
- Isolated Engine room with full-sized waterproof dogged door

MAIN DECK:

- Pilot house and captan sitting saloon

- Saloon with galley arrangement

STEEL CONSTRUCTION HULL
- Buehler design  single chine steel construction boat
- Marine Grade A certificated steel plates.
- Welded with x-ray tested.
- EU CE class A ocean certificated
- Collision, fwd stateroom, aft stateroom and engine room, watertight steel bulkheads.
- 1150 gallons fuel body tanks.
- Steel superstructure, Pilot house
- Steel pipe epoxy painted hand rails.

PAINTING SYSTEM  (Commercial Grade Painting)
- All steel construction materials (shot blasted and immediately shop primer epoxy painted )
- All outside and inside surfaces 3 layers anti-corrosion epoxy painting and 3 layers bottom.
- Underwater surfaces additional layers antifouling epoxy paints
- Polyurethane finish on superstructure surface.
- Final coating polyurethane paint above waterline.

- Wear resist commercial deck paint and non-skid walk ways on main deck

ENGINE ROOM EQUIPMENT AND PUMPS
- 125 HP Main engine Iveco.
- Onan 7.5 KVA diesel generator

- Heavy duty, vibration reducing engine mounts
- Wet exhaust system.

- Fuel double filter with water separator (secondary)
- Sea water pump for fire or deck washing.
- Rule automatic bilge pumping system for the compartments (engine room, master cabin, saloon)
- Workbench
- Ventilation including large engine room intake and exhaust blower, vented to roof.

- Diesel charged hot air heating system.
- Engine guard rail

PROPULSION
- 316 grade stainless steel propeller shaft.
- Seamless steel stern tube.
- 4 blades propeller
- Wet type rubber shaft bearings
- Rubber drip less Deep Sealing
- Elastic coupling
- Complete rudder assembly (Emergency rudder post steering arm)

- Manuel hydraulic pump for steering system.

TANK AND PIPING SYSTEM
- Plastic fresh water, grey water and black water tanks.
- Main engine steel built-in fuel tanks 1150 galons cap.
- Fresh water pressure system
- Shower, toilet, kitchen  piping and armatures.
- Fuel piping with globe valves from tank to engine system and return

- Fuel and fresh Water tanks to have closable external sight valves.

- Water tanks to have inverted "U" vents.
- Electrical marine toilet

- Propane system for stove and oven.

- Shower drain pump.

- Sea chest with strainer (single underwater through hull for all incoming water)

- Tank level indicating system and gauges.

- Quick closing valve on fuel supply line according to CE rules.

- Hot water boiler system.

- Diesel charged hot air heating system.

ANCHORAGE & MOORING SYSTEM
- 1700 watt 24 v electrical horizontal windlass, with 10 mm diam, galvanized 100 m chain.
- Bow and aft high strong  steel bollards.  .
- 75 kgs anchor

WINDOWS, GLASSES, DOORS HATCHES

- Ship grade steel windows frames and steel watertight deck doors lockable from inside and outside.
- Ship grade opening port holes with safety covers.(CE certificated)
- 10 mm tempered glass pilothouse windows.
- Ship grade steel deck hatches.
- Front screen viper.

INSULATION

- All Interior walls and ceilings are foam sprey insulation applied.
- Ceilings and walls insulated heat and noise resistant (A60) in engine room.

ELECTRICAL SYSTEM
- 24 Volt 800 Ah battery bank for servicing

- Onan 7.5 KVA diesel generator.

- Battery monitoring.

- Victron 3000 watt kombi inverter charger with control panel.
- 24 V Dual air horn and screen wiper.
- 24 V marine type interior lighting.
- DC outlets in pilothouse, galley, and saloon
- Shore power 50 amp service with GFI, 15 m. 50 amp cord
- A/C wiring size and receptacle outlets compatible with 110v and European...
- All wiring multi-stranded, tinned, in accessible conduits and above waterline.
- Shore connection panel, 24 V power panel, 24 V lighting and emergency  lighting panel,24 V  engine control and alarm panel , navigational lights panel.
- 24 V D/C ventilation fans & panel (engine, cabin, bath, kitchen.)

- Stair lighting
- Red night lighting in pilothouse
- Zincs welded on hull as per cathodic protection plan.

- Navigation lights
- Aft deck light

INTERIOR AND WOOD WORK:
- Interior walls and ceilings will be covered with selected 8mm marine ply wood, facing colour will be owner choiced.(Mahogany, teak, cherry, oak.. etc.)

- All trim in mahogany
- Mahogany safety handholds on ceilings through out
- Teak and holly interior floors through out
- Queen size bed in master cabin.
- Wardrobe, drawers, tables, sitting group in cabin and where applicable
- Wooden interior doors.
- Mostly solid mahogany wood are used in interior.
- All corners of doors, doorways, tables etc with radial (rounded) edges and corners.
- All upholstery in colour Owner choice.
- Hanging lockers and cabinets with louvered doors and marine catches in galley,

  saloon, staterooms and pilothouse.

GALLEY:
- Table, cupboard, counter top and other furniture, as indicated in spec or owner choice
- Propane system for stove&oven.
- Microwave oven installed below range
- Propane system stove&oven with 3 burner

- Single stainless sink and water taps , etc. waste basket.
- Ventilation fan over range

FORWARD BATH:

- Marine electrical toilet.
- Polyester shower pool and cabin with seat bench over convexity of hull.

- Built-in mirror
- Shower hot-cold high quality water fixtures and cabin drainage system
- 24 V ventilation fan and lighting system.
- Towel racks of handrail strength
- Overhead and under sink storage cupboards

PILOT HOUSE:
- Chart table and dashboard control panel
- Reading light
- Inverter, isolator, port wall of companion way
- Quality Teak Wood or stainless steering Wheel.
- Mahogany handholds
- Sitting group and upholstery owner’s choice
- Good quality pilot chair.
- Navigation desk with lift up top and under area storage.

SAFETY
- Life jackets 6
- Throw rings 2
- Flares
- First aid kits

- CO2 fire extinguisher (6 ).
- Life raft for 8 persons

NAVIGATIONAL ELECTRONICS
- Raymarine complete set of navigational system.(Radar, deep sounder, autopilot, vhf, gps/chartplotter) with C80 graphic display.

VENTILATION
- Engine room: Intake and exhaust blowers.
- Bath: Ventilation fan
- Black water waste tanks: Air vent pipes
- Portholes that open.
- Galley: Range hood  exhaust fan.

MAST AND SAIL RIG AS BUEHLER SPEC
- Aluminium sail mast.
- Stainless steel stays and wires, stainless steel lifting,
- Manual rope winches.